Brave VH0622 Specifikace

Owner / Operator and Safety ManualSee initial start-up instructions on page oneBBrraavvee 2222 aanndd 2266 TToonnVertical / HorizontalLog Splitter

Required Tools• 10” crescent wrench• Flat head screwdriver• Two 1/2’’ open end wrenches• Two 3/4” open end wrenches• Funnel• Pliers• Band CuttersShipp

Unpacking the Crate1. Cut the metal banding and remove the top,sides, ends, and protective plastic cover-ing of the packing crate. Do not unband orr

Assembly ProcedureSome components are very heavy and can be damaged if mishandled. Tohelp prevent personal injury, it is strongly recommended that t

5. Lift the front leg and carefully roll the baseunit off the pallet.6. Carefully stand the rail assembly in anupright, vertical position.Make sure

9. Put one foot on the base plate of the frontleg to prevent the log splitter from tippingup and lower the rail to a horizontal position.NOTE: Block

13. Insert the chain link into the valve bodyas shown, with the pins facing upward.14. Position the control lever as shown andinstall it onto the ch

17. Attach high-pressure hose (A) to the bot-tom valve fitting.NOTE: The high-pressure hose is self-seal-ing and does not require any type of sealing

21. The log splitter is now completely assembled. Follow the “Start-Up Procedure”,in the following section, which adds oil to the engine and hydraul

Important NoticeFollow all the instructions listed below before starting or operating your log split-ter. Failure to do so may result in engine and h

Important NoticeIf your log splitter is equipped with a factory installed engine, do not mix oilwith the gasoline. Using mixed oil/gasoline in a four

❏❏Read all assembly, operating, and safety instructions.❏❏Complete and return the warranty card to register your log splitter.❏❏Write the serial numbe

Maximum Speed Limit — 35 mphYour log splitter is built on a solid, unsuspended axle. To prevent damage orpossible loss of vehicle control, use extrem

Do not attempt to operate the log splitter without fully understandingall our instructions, safety precautions, and/or warnings. If any doubt or quest

Never attempt to split wood across thegrain. The log splitter was not designed forcross-grain splitting. Doing so will dam-age the log splitter and

b. Only using your hand, push the controllever forward (towards the log). If thelog moves before it is contacted by thesplitting wedge, release the

Do not reach or step across therail while the log splitter is run-ning. This is a very UNSAFEmethod which could cause personal injuryor even death.5

7. When the cylinder is fully retracted, thecontrol valve will automatically shift to theNeutral position.Operation – Vertical Position1. Use the fo

Do not place your hands on topof the log when loading the logsplitter. This is a very UNSAFEmethod and could result in injury to yourhands.Do not put

b. Operate the log splitter only whenstanding in the safe operating area,as shown in the picture.Make sure you stand clear from theengine’s exhaust.

4. It is not necessary to hold the control lever.The cylinder rod will automatically retract,and when its fully retracted, the handlereturns to Neutr

General Maintenance Check (before operating)The hydraulic system (hoses, cylinder, and pump) should be carefully inspected beforeeach use. Also, insp

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2Safety . . . . . . . . .

Hydraulic Oil ChangeBrave Products recommends an oil and filter change every 100 hours of operation. Referto the “Specifications” section in this man

Important NoticeDO NOT mix tractor hydraulic oil with transmission fluid. Use one or the other.4. Refill the hydraulic tank.a. Reconnect inlet hose

Mechanical SpecificationsSlide Rail . . . . . . . . . . . . . . . . . . . . . 3 x 6 inch reinforced, heavy-duty formed channelWedge . . . . . . . . .

The following section details procedures for checking your log splitter, should youencounter a malfunction. Brave Products, Inc. recommends that you

Make sure all decals are attached to the log splitter and/or engine andare legible at all times. If you are missing a decal or one is not legible,cal

800-350-873933Brave Products, Inc.DecalsItem Part No. Description Qty.1 BR002302 Decal, Operator Safety 12 BR002652 Decal, Notice 13 BR002521 Decal, S

For one year from the date of purchase, Brave Products Inc. will replace for the originalpurchaser, or repair free of charge, all parts of the Brave P

800-350-873935Brave Products, Inc.Notes

Brave Products, Inc.36815-672-8861Parts2Part of Model VH0626 only.Item Part No. Description Qty1 BR001321 Locknut, 1/2-13 32 BR021263 Weldment, Tank H

800-350-873937Brave Products, Inc.Parts242527201112224261718191615443325532861412131199810B22/26-487, 2326

These professional quality VH0622 and VH0626 Vertical/Horizontal Log Splitters aredesigned for tough applications in both vertical and horizontal posi

Brave Products, Inc.38800-350-8739PartsItem Part No. Description Qty1 BR021262 Weldment, Rail 12 BR021163 Weldment, Slide Wedge 13 BR013102 Guide, Sli

800-350-873939Brave Products, Inc.Parts89101112131265311417154B22/26-497216

Brave Products, Inc.40800-350-8739Item Part No. Description Qty1 BR0030091Engine, Briggs, 6.5 HP 1BR0030132Engine, Briggs, 8 HPBR0030192Engine, Honda,

800-350-873941Brave Products, Inc.251625131281110974562331515181917242726141B22/26-502221202328208142929Parts

These attachments are designed to fit both Brave 22 and 26 ton log splitters.Log Cradle (Part No. BR021181)✔ Holds log in place on top of rail for fa

Important Warranty InformationTo activate your Brave Products’ log splitter warranty, please fill out the information in the form below, clip out the

NotesBrave Products, Inc.44800-350-8739

Notes800-350-873945Brave Products, Inc.

Brave Products, Inc.410 W. Broadway Ave.Streator, Illinois 61364-0577Phone: 815-672-8861 Fax: 815-672-9073E-mail: [email protected] Site: w

Safety Alert SymbolThe safety alert symbol is used to identify safety information about hazards that canresult in personal injury.A signal word (WARN

DO NOT proceed if any doubt arises about the correct or safe method of performing any-thing found in this or other Brave Products’ manuals. Seek out

Operating Safety✔ ALLOW ONLY ONE (1) PERSON TO LOAD AND OPERATE THE LOG SPLIT-TER.✔ Allow only adults to operate the log splitter - no one under the a

✔ ALWAYS make sure that both ends of the log you are splitting are cut as squareas possible. This will prevent the log from sliding out of position wh

✘ NEVER tow your log splitter when there is fuel in the engine’s tank.✘ NEVER allow anyone to sit or ride on your log splitter.✘ NEVER carry any cargo